表面喷砂对有机玻璃沿面闪络性能影响

绝缘子表面粗糙处理是提升其沿面闪络性能的重要途径,表面粗糙化处理方式不当,极易带来表面结构不均匀,难以获得稳定耐压性能的绝缘材料。为提升绝缘子表面粗糙处理的均匀性,本文利用表面喷砂技术对圆柱形有机玻璃(PMMA)绝缘子进行了粗糙化处理研究,以球形二氧化硅(SiO2)颗粒为工作介质,研究了不同喷砂粒径、氢氟酸后处理等因素对绝缘材料表面形貌和组分的影响,并利用短脉冲高压测试平台对喷砂处理前后有机玻璃绝缘子样品进行了真空沿面闪络性能测试。研究结果表明,喷砂处理在有机玻璃表面形成了较为均匀的凹坑,HF酸能够有效去除表面残留的SiO2颗粒,具有表面喷砂粗糙结构的绝缘子沿面闪络电压得到了稳定提升,相较于未处理的绝缘子闪络电压提升了约80%。     

电感耦合等离子体质谱(ICP-MS)法测定离子吸附型稀土矿中的浸出稀土元素

对浙江某地大量的离子吸附型稀土样品进行了稀土元素(Y,La,Ce,Pr,Nd,Sm,Eu,Gd,Tb,Dy,Ho,Er,Tm,Yb,Lu)的浸提和测定实验,实验对比了氯化铵和硫酸铵溶液对矿石中稀土元素的浸出性能,选择了杂质浸出较少的硫酸铵溶液作为浸出剂,对不同稀土含量的吸附型稀土矿进行了实验,浸出方法稳定,符合工业开采要求。实验了电感耦合等离子体质谱法测定浸出液中稀土元素分量的方法,浸出液经大比例稀释并酸化后测定,精密度较好,能满足离子吸附型稀土矿评价的质量要求,方法检出限(6σ)0.005~0.26μg/g,单元素测定精密度(n=6,RSD≤6.0%),浸出稀土元素总量测定RSD≤4.0%。实际样品的实验及测定结果满意。     

Experimental analysis of sand particles'' lift-off and incident velocities in wind-blown sand flux

The probability distributions of sand particles' lift-off and incident velocities in a wind-blown sand flux play very important roles in the simulation of the wind-blown sand movement. In this paper, the vertical and the horizontal speeds of sand particles located at 1.0 mm above a sand-bed in a wind-blown sand flux are observed with the aid of Phase Doppler Anemometry (PDA) in a wind tunnel. Based on the experimental data, the probability distributions of not only the vertical lift-off speed but also the lift-off velocity as well as its horizontal component and the incident velocity as well as its vertical and horizontal components can be obtained by the equal distance histogram method. It is found, according to the results of the χ²-test for these probability distributions, that the probability density functions (pdf's) of the sand particles' lift-off and incident velocities as well as their vertical components are described by the Gamma density function with different peak values and shapes and the downwind incident and lift-off horizontal speeds, respectively, can be described by the lognormal and the Gamma density functions. These pdf's depend on not only the sand particle diameter but also the wind speed. The project supported by the National Natural Science Foundation of China (10532040) and the Hundred Talents Project, the Knowledge Innovation Project of Chinese Academy of Sciences (KZCX2-304). The English text was polished by Keren Wang.     

On the Validity of Darcy's Law for Stable High-Concentration Displacements in Granular Porous Media

Recently, it has been suggested that Darcy's Law might not be applicable for modelling miscible, density-dependent flow in porous media. To investigate this, three sets of careful laboratory column experiments were performed on coarse and medium sands, consisting of upward displacement of water by sodium chloride solutions with concentrations ranging from 5 to 200g/l. Data on salt concentrations and water pressures were collected in horizontal transects along the flow direction. Salt concentration data were also collected in the influent and exit lines. The experimental data were analysed using a simplified approach based on Darcy's Law alone, applied with the assumption of a sharp interface. Darcy's Law was used to estimate porous medium permeability by fitting predictions to experimental data. Consistent estimates of permeability were obtained for each set of experiments. The results indicate that Darcy's Law adequately describes high concentration displacements through saturated coarse- and medium-grained porous media.     

大型砂尘风洞中砂尘浓度测量与控制方法的研究

砂尘浓度指标严重影响砂尘风洞试验效果;在大型砂尘风洞中准确的测量及有效的控制砂尘浓度是砂尘风洞设备研制中的两个关键问题;针对动态试验工况环境中浓度传感器标定的问题,分析了浓度测量时标定参数与风速和浓度的关系,使用模型树算法建立了三者之间的关系模型,以此模型来预测各种动态情况下的标定参数;针对复杂环境下浓度动态控制问题,采用专家PID算法,提出了多回路控制系统结构和专家规则;工程实践表明该测量和控制方法满足了动态试验环境的需求,取得了良好效果;模型树算法和专家PID系统能有效的解决动态工况下砂尘浓度的测量与控制问题。     

地表温度对颗粒跃移轨迹的影响

为了研究由地表温度变化引起的向上的垂向气流对沙粒跃移运动的影响,本文给出了考虑近地表温度变化和水平来流风场作用下的沙粒的跃移运动。在定量给出不同时刻的近地表温度和垂向风速的基础上,计算了由于太阳辐射所引起的近地表层垂向气流对沙粒跃移运动的影响,发现:垂向风速在午后可达到1.5m/s并使得沙粒跃移轨迹的最大高度和长度分别增加55.56%和73.68%;同时,与不考虑温度效应的情况不同的是,沙粒跃移轨道最大高度将随粒径变化。     

组合单元法在砂井地基有限元分析中的应用

针对砂井地基的平面应变有限元分析，本文首次将组合单元法引入到砂井地基的分析中，提出砂墙组合单元。该单元对常规等参元进行改进，在单元内部同时考虑砂井的涂抹作用和井阻作用，从而克服了常规有限元法在计算砂井地基时单元数和节点数过多的缺点。将砂墙组合单元加入USAP有限元计算软件，工程算例分析结果表明：与已有的各砂井地基的平面应变解答和荷兰的基础工程有限元分析软件PLAXIS相比，解答合理并有效地考虑砂井的涂抹作用和井阻作用；与常规有限元法相比，在保证计算精度的前提下，减少了可观的单元数和节点数，降低了计算的工作量。     

颗粒型砂介质的受压力学特征及屈服滑动

提出颗粒型砂介质在压实过程中的两种特征：孔隙填充状态和颗粒滑动状态；针对孔隙填充状态的力学行为特征，提出相对体积改变量(压实量)作为表征此状态的特征参量，研究了瞬时压缩模量与压实量的函数关系；针对型砂的颗粒滑动状态，提出具有强化效应的Mohr-Coulomb屈服条件，推导描述颗粒屈服滑动状态的增量本构方程、以及三轴压实过程条件下的状态本构方程，最后，就不同侧向压力下的三轴压缩试验、带模样的型砂压实试验的大量试验数据进行处理和验证。     

Evolution of downsized crescent-shaped dune in wind tunnel experiment

The migration of a downsized crescent-shaped dune was investigated in a wind tunnel experiment.Quantified upwind influx and vertical oscillation of the sand bed were introduced to modulate the saturation level of the sand flux above the dune surface to affect dune evolution.The evolution was recorded by top-view photography and then abstracted as the evolution of self-defined characteristic quantities using a digital image processing algorithm.The results showed that,in contrast to the case for spanwise quantities,the evolution of streamwise quantities corresponds to a linear increase in the modulation magnitude more positively and in a monotonic and convergent manner.In contrast with quantities on the windward face,the changes in quantities with respect to the horns were nonmonotonic with time and almost uncorrelated with the variation in modulation strength,which reveals the distinctiveness of leeside evolution.     

利用三维随机模型分析沥青混合料的蠕变行为

将沥青混合料看作由粗骨料和沥青砂组成的两相复合材料,根据给定的级配生成凸多面体骨料,然后利用随机投放算法建立沥青混合料试样的三维随机模型.采用广义Maxwell模型刻画沥青砂的本构行为,其参数通过单轴蠕变实验获得.在对三维随机模型的有效性进行验证之后,采用参数化建模方法建立包含不同骨料分布、含量和级配的沥青混合料有限元模型,通过数值模拟研究骨料分布、含量和级配对沥青混合料蠕变行为的影响.结果表明:骨料分布对沥青混合料力学性质的影响较小;沥青混合料瞬时弹性模量随骨料含量的增加呈近似线性增大,而且弹性模量与骨料含量之间的关系曲线处于Paul上下边界内;在计算考虑的粒径范围内,骨料平均粒径越小,沥青混合料抵抗变形的能力越强.